Name:	2-Diethylaminoethyl Chloride Hydrochloride 99.5% Material Safety Data Sheet
Synonym:	2-Chloro-N,N-Diethylethylamine Hydrochloride; 2-Chlorotriethylamine Hydrochloride; DE
CAS:	869-24-9

Section 1 - Chemical Product   MSDS Name:2-Diethylaminoethyl Chloride Hydrochloride 99.5% Material Safety Data Sheet
Synonym:2-Chloro-N,N-Diethylethylamine Hydrochloride; 2-Chlorotriethylamine Hydrochloride; DE

---

Section 2 - COMPOSITION, INFORMATION ON INGREDIENTS

CAS#	Chemical Name	content	EINECS#
869-24-9	2-Diethylaminoethylchloride Hydrochlor	99.5	212-786-4

Hazard Symbols: T+
Risk Phrases: 26 36/37/38 24/25

---

Section 3 - HAZARDS IDENTIFICATION
  EMERGENCY OVERVIEW
Very toxic by inhalation. Irritating to eyes, respiratory system and skin. Toxic in contact with skin and if swallowed.Hygroscopic (absorbs moisture from the air).The toxicological properties of this material have not been fully investigated.
Potential Health Effects
Eye:
Causes eye irritation.
Skin:
Causes skin irritation. May be fatal if absorbed through the skin.
May cause dermatitis.
Ingestion:
May be fatal if swallowed. Causes gastrointestinal irritation with nausea, vomiting and diarrhea. The toxicological properties of this substance have not been fully investigated. May cause burning sensations, coughing, wheezing, laryngitis, shortness of breath and headache.
Inhalation:
May be fatal if inhaled. Causes respiratory tract irritation. The toxicological properties of this substance have not been fully investigated. May cause dyspnea (difficult or labored breathing). May cause burning sensation, coughing, wheezing, laryngitis, shortness of breath, headache, nausea, and vomiting.
Chronic:
Laboratory experiments have resulted in mutagenic effects.

---

Section 4 - FIRST AID MEASURES
  Eyes: Immediately flush eyes with plenty of water for at least 15 minutes, occasionally lifting the upper and lower eyelids. Get medical aid immediately.
Skin:
Get medical aid immediately. Immediately flush skin with plenty of water for at least 15 minutes while removing contaminated clothing and shoes.
Ingestion:
Never give anything by mouth to an unconscious person. Get medical aid immediately. Do NOT induce vomiting. If conscious and alert, rinse mouth and drink 2-4 cupfuls of milk or water.
Inhalation:
Get medical aid immediately. Remove from exposure and move to fresh air immediately. If breathing is difficult, give oxygen. Do NOT use mouth-to-mouth resuscitation. If breathing has ceased apply artificial respiration using oxygen and a suitable mechanical device such as a bag and a mask.
Notes to Physician:
Treat symptomatically and supportively.

---

Section 5 - FIRE FIGHTING MEASURES
  General Information:
As in any fire, wear a self-contained breathing apparatus in pressure-demand, MSHA/NIOSH (approved or equivalent), and full protective gear. During a fire, irritating and highly toxic gases may be generated by thermal decomposition or combustion.
Extinguishing Media:
Use water spray, dry chemical, carbon dioxide, or appropriate foam.

---

Section 6 - ACCIDENTAL RELEASE MEASURES
  General Information: Use proper personal protective equipment as indicated in Section 8.
Spills/Leaks:
Clean up spills immediately, observing precautions in the Protective Equipment section. Sweep up, then place into a suitable container for disposal. Avoid generating dusty conditions. Provide ventilation. Do not get water inside containers.

---

Section 7 - HANDLING and STORAGE
  Handling:
Wash thoroughly after handling. Avoid contact with eyes, skin, and clothing. Keep container tightly closed. Avoid ingestion and inhalation. Do not allow contact with water. Use only in a chemical fume hood. Wash clothing before reuse. Keep from contact with moist air and steam.
Storage:
Store in a tightly closed container. Store in a cool, dry, well-ventilated area away from incompatible substances. Poison room locked. Store protected from moisture.

---

Section 8 - EXPOSURE CONTROLS, PERSONAL PROTECTION
  Engineering Controls:
Facilities storing or utilizing this material should be equipped with an eyewash facility and a safety shower. Use adequate ventilation to keep airborne concentrations low.
Exposure Limits CAS# 869-24-9: Personal Protective Equipment Eyes: Wear appropriate protective eyeglasses or chemical safety goggles as described by OSHA's eye and face protection regulations in 29 CFR 1910.133 or European Standard EN166.
Skin:
Wear appropriate protective gloves to prevent skin exposure.
Clothing:
Wear appropriate protective clothing to prevent skin exposure.
Respirators:
Follow the OSHA respirator regulations found in 29 CFR 1910.134 or European Standard EN 149. Use a NIOSH/MSHA or European Standard EN 149 approved respirator if exposure limits are exceeded or if irritation or other symptoms are experienced.

---

Section 9 - PHYSICAL AND CHEMICAL PROPERTIES
 
Physical State: Crystalline powder
Color: white to beige
Odor: characteristic odor
pH: 5 (100g/l aq. sol.)
Vapor Pressure: Not available.
Viscosity: Not available.
Boiling Point: Not available.
Freezing/Melting Point: 208.00 - 212.00 deg C
Autoignition Temperature: Not available.
Flash Point: Not available.
Explosion Limits, lower: Not available.
Explosion Limits, upper: Not available.
Decomposition Temperature: > 220 deg C
Solubility in water: 2000 g/l (20 c)
Specific Gravity/Density:
Molecular Formula: C6H14ClN.HCl
Molecular Weight: 172.10

---

Section 10 - STABILITY AND REACTIVITY
  Chemical Stability:
Stable at room temperature in closed containers under normal storage and handling conditions. Hygroscopic: absorbs moisture or water from the air.
Conditions to Avoid:
Dust generation, moisture.
Incompatibilities with Other Materials:
Strong oxidizing agents, strong bases.
Hazardous Decomposition Products:
Hydrogen chloride, nitrogen oxides, carbon monoxide, carbon dioxide.
Hazardous Polymerization: Has not been reported.

---

Section 11 - TOXICOLOGICAL INFORMATION
  RTECS#:
CAS# 869-24-9: YE1050000 LD50/LC50:
CAS# 869-24-9: Draize test, rabbit, eye: 100 mg Severe; Draize test, rabbit, skin: 500 mg Severe; Inhalation, rat: LC50 = 103 mg/m3/4H; Oral, rat: LD50 = 50 mg/kg; Skin, rabbit: LD50 = 125 mg/kg.
LC50 1Hr (dust) = .412mg/L or 58.53ppm Carcinogenicity:
2-Diethylaminoethylchloride Hydrochloride - Not listed by ACGIH, IARC, or NTP.
Other:
See actual entry in RTECS for complete information.

---

Section 12 - ECOLOGICAL INFORMATION
 

---

Section 13 - DISPOSAL CONSIDERATIONS
  Dispose of in a manner consistent with federal, state, and local regulations.

---

Section 14 - TRANSPORT INFORMATION
 
IATA
Shipping Name: TOXIC SOLIDS, ORGANIC, N.O.S.
Hazard Class: 6.1
UN Number: 2811
Packing Group: I
IMO
Shipping Name: TOXIC SOLIDS, ORGANIC, N.O.S.
Hazard Class: 6.1
UN Number: 2811
Packing Group: I
RID/ADR
Shipping Name: TOXIC SOLIDS, ORGANIC, N.O.S.
Hazard Class: 6.1
UN Number: 2811
Packing group: I

---

Section 15 - REGULATORY INFORMATION
 
European/International Regulations
European Labeling in Accordance with EC Directives
Hazard Symbols: T+
Risk Phrases:
R 24/25 Toxic in contact with skin and if swallowed.
R 26 Very toxic by inhalation.
R 36/37/38 Irritating to eyes, respiratory system
and skin.
Safety Phrases:
S 26 In case of contact with eyes, rinse immediately
with plenty of water and seek medical advice.
S 28A After contact with skin, wash immediately with
plenty of water.
S 36/37/39 Wear suitable protective clothing, gloves
and eye/face protection.
S 45 In case of accident or if you feel unwell, seek
medical advice immediately (show the label where
possible).
WGK (Water Danger/Protection)
CAS# 869-24-9: 2
Canada
CAS# 869-24-9 is listed on Canada's DSL List.
CAS# 869-24-9 is not listed on Canada's Ingredient Disclosure List.
US FEDERAL
TSCA
CAS# 869-24-9 is listed on the TSCA inventory.

---

SECTION 16 - ADDITIONAL INFORMATION
N/A